Complaint volume
1135 consumer-submitted complaints are matched to this model year. Treat the count as a research signal, then read the actual summaries for repeated symptoms.
Complaint records
2020 Ford Explorer Complaints
1135 consumer-submitted complaints on record for the 2020 Ford Explorer, grouped by component category.
1135 Total complaints
33 Crash reports
10 Fire reports
27 Injury reports
Complaint data reflects consumer-submitted reports. A complaint is not proof
of a defect, recall, or manufacturer fault. Enriched severity fields come
from official bulk records when the complaint can be matched by ODI number.
Buyer interpretation
How to use these complaints before buying
Complaint records are most useful when they turn into inspection points, seller questions, and comparison checks against nearby model years.
Pattern to inspect
The most common categories are power train, unknown or other, back over prevention. Use those categories as a test-drive checklist instead of judging the vehicle from the total count alone.
Severity flags
Enriched records include 33 crash reports, 10 fire reports, 27 injury reports, and 0 fatality reports. These fields come from complaint records and should be read in context.
Mileage clue
Mileage is available on 385 complaints, with an average reported failure mileage of 33,892 miles. Compare that with the mileage on the listing.
Questions to ask the seller
- Have you had any problems related to power train, unknown or other, back over prevention?
- Can I see recent maintenance and repair records?
- Has the vehicle ever been towed, involved in a crash, or repaired for the same issue twice?
- Can we also check the recall record for this 2020 Ford Explorer?
Used-car checklist
Use these complaints before the test drive.
Build a buyer checklist to turn these issues into questions and inspection points.
2020 Ford Explorer
Build buyer checklist Compare with other years Sends year, make, and model to pre-fill your checklist.
How severe are the 2020 Ford Explorer complaints?
33 Crash
10 Fire
27 Injury
0 Fatality
40 Towed
8 Medical attention
What are the most common 2020 Ford Explorer complaint categories?
POWER TRAIN 307
UNKNOWN OR OTHER 117
BACK OVER PREVENTION 56
ELECTRICAL SYSTEM 44
ENGINE 42
EXTERIOR LIGHTING 40
SERVICE BRAKES 27
VISIBILITY/WIPER 27
STRUCTURE 26
SEATS 25
1,135 total complaints on record
Latest complaints
| Date | Component | Summary | Severity | Mileage |
|---|---|---|---|---|
| Jul 2020 | ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC) | I HAVE NUMEROUS FAULT MESSAGES, PRE COLLISION ASSIST FAULT, 4WD TEMP DISABLED, 4WD SYSTEM FAULT SERVICE REQUIRED, SERVICE REQUIRED, DRIVE MODE UNAVAILABLE FAULT,AUTO HOLD SYSTEM FAULT,SERVICE ADVANCETRAC, VEHICLE WILL NOT SWTICH INTO PARK OR NEUTRAL. I WAS IN MOTION AT THE STATE SPEED LIMIT OF 70 ON THE OHIO TURNPIKE WHEN OUT OF THE BULE THE WARNING CLUSTER LIT UP LIKE A CHRISTMAS TREE WITH MUTIPLE FAULTS AND SYSTEM ERRORS. VEHICLE HAS LIMITED BRAKING. | Crash: No Fire: No | 4,500 |
| Jul 2020 | POWER TRAIN,ENGINE | I WAS DRIVING GOING TO GET FOOD AND WHEN I PRESS ON MY BREAK TO SLOW DOWN, I HAD A HUGE JOLT, LIKE IT WAS SHIFTING GEARS NOT CORRECTLY(IT'S AN AUTOMATIC)THE JOLT WOULD OCCUR WHEN I WOULD HIT OVER 46MPH AND WHEN I WOULD SLOW DOWN TO 26MPH. I BROUGHT MY EXPLORER TO THE DEALERSHIP AND I HAD TO HAVE MY TRANSMISSION REPLACED BY THE DEALERSHIP.I HAVE HEARD OF 3 OTHER PEOPLE WHO HAD A FORD EXPLORER 2020 THIS HAPPENED TO! | Crash: No Fire: No | 1,100 |
| Jul 2020 | ELECTRICAL SYSTEM,SERVICE BRAKES | SEVERAL TIMES THE REVERSE CAMERA AND SENSOR HAVE NOT WORKED (BLUE SCREEN) ONE OF THE TIMES ALMOST HITTING A CAR BEHIND ME, ONCE THE CENTER SCREEN WENT BLACK WHILE DRIVING WHILE USING THE NAVIGATION SYSTEM, THIS MORNING, PUT THE TRANSMISSION IN REVERSE AND THE BRAKE PEDAL BECAME REALLY HARD WHEN STEPPING ON IT AND AGAIN ALMOST HIT A CAR BEHIND ME, SUDDENLY IT WENT TO THE FLOOR CAUSING THE CAR TO STOP SUDDENLY ALL THIS WHILE GETTING OUT OF A PARKING SPACE | Crash: No Fire: No | Unknown |
| Jul 2020 | POWER TRAIN,SERVICE BRAKES,ENGINE | 2020 FORD EXPLORER ST WITH APPROXIMATELY 1,927 MILES. I STARTED THE VEHICLE AND PUT IT INTO DRIVE AND IT STARTED TO ROLL FORWARD EVEN THOUGH MY FOOT WAS ON THE BRAKE. REGARDLESS OF HOW HARD I PUSHED THE BRAKE, THE CAR CONTINUED TO INCH FORWARD UNTIL I FULLY DEPRESSED/REPRESSED THE BRAKE. I SHUT OFF THE VEHICLE, WAITED A FEW MINUTES, AND ATTEMPTED TO RESTART. UPON THE ATTEMPTED RESTART, ALL LIGHTS ON THE DASHBOARD BEGAN FLASHING AND THE ENGINE FAILED TO TURNOVER. THE IN-DASH DISPLAY THEN BEGAN BEEPING, FLASHING SERVICE/HAZARD/WARNING INDICATORS, AND CYCLING THROUGH THE FOLLOWING ERROR MESSAGES: -PARK BRAKE FAULT SERVICE NOW; -PRE-COLLISION ASSIST NOT AVAILABLE; -SERVICE ADVANCETRAC; -DRIVER DOOR AJAR; -STEERING ASSIST FAULT SERVICE REQUIRED; -CHECK PARK AID; -SEE MANUAL; -FRONT CAMERA FAULT SERVICE REQUIRED; -FULL ACCESSORY POWER ACTIVE; I TURNED OFF THE VEHICLE AND ATTEMPTED A FEW MORE RESTARTS RANGING IN INTERVALS FROM AN IMMEDIATE START/STOP, 1 MINUTE, 5 MINUTES, AND 10 MINUTES WITHOUT SUCCESS (SAME ERROR MESSAGES DISPLAYED AS DESCRIBED ABOVE). THERE WERE ALSO NO ALERT MESSAGES/NOTIFICATION IN THE FORDPASS MOBILE APP INDICATING THE ABOVE FAILURES. MY NEXT ATTEMPT WAS A FEW HOURS LATER AND THE VEHICLE STARTED WITHOUT ERROR, BUT DID NOT GIVE ANY INDICATION THAT THE VEHICLE HAD FAILED TO START THE PREVIOUS TIME. I STOPPED/RESTARTED THE VEHICLE AGAIN WITHOUT ERROR AND PUT IT INTO REVERSE AND THEN DRIVE AND THERE DID NOT APPEAR TO BE ANY FAILURE OF THE BRAKE PEDAL. I TOOK THE VEHICLE FOR A TEST DRIVE AROUND MY NEIGHBORHOOD AND NOTICED THAT 1ST AND 2ND GEAR APPEARED TO SHIFT JUST FINE, 3RD GEAR MADE A LOUD GRINDING/VIBRATING NOISE AND TOOK LONGER TO SHIFT THAN NORMAL, AND THEN THE VEHICLE DID A HARD SHIFT INTO 4TH GEAR. I ONLY GOT UP TO ABOUT 35 MILES PER HOUR, BUT THE VEHICLE NEVER SHIFTED OUT OF 4TH GEAR, BUT APPEARED TO HOLD THE RPMS HIGHER THAN NORMAL. | Crash: No Fire: No | 1,927 |
| Jul 2020 | POWER TRAIN,ELECTRICAL SYSTEM | I JUST PULLED OUT FROM A PARKING LOT INTO TRAFFIC AND THERE WAS A LOUD CLUNK AND WARNING LIGHTS APPEARED ON THE DASH. ONE SAID "SERVICE ADVANCETRAC" AND THE OTHER SAID "4WD FAULT SERVICE REQUIRED." THE VEHICLE WOULD NOT SHIFT OUT OF LOW GEAR AND WOULD NOT ACCELERATE OVER 25MPH. THEN, SEVERAL OTHER WARNING LIGHTS CAME ON, SUCH AS "PRE-COLLISION ASSIST NOT AVAILABLE." I TOOK THE VEHICLE TO THE DEALERSHIP THE NEXT DAY AND THEY WERE UNABLE TO REPAIR/RESOLVE THE ISSUE. | Crash: No Fire: No | 832 |
| Jul 2020 | UNKNOWN OR OTHER | THE ELECTRONICS IN SYNC HAVE BEEN GENERATING BLUE SCREENS, WHICH DISABLE: TRONT & REAR SENSORS & CAMERAS, FRONT & REAR COLLISION AVOIDANCE, CRUISE CONTROL, LANE DEPARTURE, AND ADVANCETRAC. FORD THUS FAR IS UNABLE TO FIX ISSUE. 3 ATTEMPTS HAVE BEEN MADE TO FIX THIS, A 4TH IS PENDING. FORD SUPPOSEDLY HAS NO REPAIR PARTS AVAILABLE FOR THIS ISSUE. VEHICLE SAFETY IS AN ISSUE. TWO FORD CASES HAVE BEEN OPENED: FORD VEHICLE BUY BACK CASE NO.[XXX]CRM:0688061 FORD SYNC PROBLEMS CASE NO.[XXX]CRM:0382088 INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). | Crash: No Fire: No | 4,500 |
| Jul 2020 | SERVICE BRAKES | ON OCCASION, THE BRAKES DO NOT WORK PROPERLY WHEN THE CAR IS FIRST PUT INTO DRIVE OR REVERSE AFTER STARTING. WHEN SHIFTING INTO DRIVE OR PARK WITH THE FOOT FIRMLY ON THE BRAKE, THE VEHICLE BEGINS TO MOVE, AND THE BRAKE PEDAL DOES NOT DEPRESS ALL THE WAY AND DOES NOT STOP THE VEHICLE FROM MOVING. IF YOU ATTEMPT TO PUMP THE BRAKES, THERE IS A HARD STOP THAT PREVENTS THE BRAKE PEDAL FROM GOING ALL THE WAY TO THE FLOOR. THE ONLY WAY TO STOP THE VEHICLE IS TO PUT IT BACK INTO PARK. *TR | Crash: No Fire: No | 2,000 |
| Jun 2020 | SERVICE BRAKES | AFTER STARTING THE VEHICLE IN PARK AND WITH BRAKE DEPRESSED SHIFTING TO REVERSE THE CAR MOVES REGARDLESS OF BRAKE PRESSURE APPLIED. ISSUE ONLY STOPS AFTER PUMPING THE BRAKES OR SHIFTING BACK TO PARK OUR NEUTRAL. ALL SITUATIONS HAVE BEEN ON FLAT LAND AND HAS OCCURRED WITH MULTIPLE DRIVERS. BRAKE PEDAL IS NOTED TO BE 'HARD' WHEN EVENT OCCURS, ALMOST LIKE IT IS LOCKED. | Crash: No Fire: No | 8,000 |
| Jun 2020 | VEHICLE SPEED CONTROL | TL* THE CONTACT OWNS A 2020 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED HOWEVER, THE VEHICLE FAILED TO RESPOND. THE CONTACT STATED THAT SEVERAL UNKNOWN WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE DEALER WAS NOT MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 10,200. | Crash: No Fire: No | 10,200 |
| Jun 2020 | POWER TRAIN | TL* THE CONTACT OWNS A 2020 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THERE WAS AN ABNORMAL SOUND COMING FROM THE VEHICLE. THE VEHICLE WAS DRIVEN TO THE RESIDENCE AND THE CONTACT DISCOVERED AN UNKNOWN LEAK. THE VEHICLE WAS TAKEN TO BOGGUS FORD (2521 SOUTH EXPRESSWAY 83, HARLINGTON, TX 78550 (956)423-2580, TO BE INSPECTED. THE CONTACT WAS INFORMED THAT WHEN THE TRANSMISSION COOLANT SYSTEM CAME IN CONTACT WITH AIR, THE TRANSMISSION COOLANT LINES WOULD LEAK. THE TRANSMISSION FLUID SYSTEM WAS REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 6,000. | Crash: No Fire: No | 6,000 |
| Jun 2020 | ENGINE | ON SUNDAY, JUNE 14TH, 2020 AT 12:10 PM, I WAS HEADED EAST BOUND ON A TWO LANE STATE ROAD WITH DOUBLE YELLOW LINES. MY VEHICLE (NEW FORD EXPLORER ST, 2407 MILES ON ODOMETER) WAS ON INTELLIGENT CRUISE CONTROL SET FOR 37 MPH AND IN 'NORMAL DRIVE' MODE. WITHOUT ANY WARNING, THE ENGINE BEGAN TO SHAKE VIOLENTLY AND THE CAR BEGAN TO SLOW DOWN. THE ENGINE APPEARED TO BE RUNNING BUT WOULD NOT ACCELERATE. THE VEHICLE CAME TO A COMPLETE STOP ABOUT 300 FEET FROM WHERE THE PROBLEM STARTED. THE ENGINE WAS STALLED AND WOULD NOT START. NO WARNING LIGHTS OR MESSAGES. CALLED AAA AND THEY CALLED LOCAL POLICE. AN OFFICER DIRECTED TRAFFIC AS I WAS BLOCKING THE RIGHT HAND LANE. THERE WAS NO SHOULDER TO PULL OFF ON. ROAD WAS IN RESIDENTIAL AREA WITH CURBS. A FLAT BED TOW TRUCK ARRIVED AT 12:35 PM AND TOWED THE VEHICLE TO MY LOCAL FORD DEALER. FAULT CODE SHOWED A DEFECTIVE CAMSHAFT POSITION SENSOR. THERE ALSO IS EVIDENCE THAT THE TIMING BELT HAS SLIPPED. SCORING CAN BE SEEN ON TOP OF #6 PISTON THROUGH BORESCOPE. THE #6 SPARK PLUG SHOWS IMPACT DAMAGE FROM PISTON. BATTERY IS DRAINING AND CAR IS GOING INTO SLEEP MODE. SERVICE DEPARTMENT MANAGER STATED THE ENGINE WILL LIKELY REQUIRE REPLACEMENT. THE DEALERSHIP CONTACTED FORD ENGINEERING AND ESTABLISHED A CASE NUMBER. DEALERSHIP IS WORKING WITH FORD ENGINEERING TO DETERMINE THE ROOT CAUSE OF FAILURE. A CATASTROPHIC ENGINE FAILURE OF THIS TYPE IS EXTREMELY DANGEROUS AND LIFE THREATENING. THREE DAYS EARLIER, A 140 MILE ROUND TRIP WAS MADE TO BOSTON WITHOUT INCIDENT. IF THE FAILURE HAD OCCURRED ON I-93 TRAVELING AT 70 MPH, THE END RESULT COULD HAVE BEEN DISASTROUS. | Crash: No Fire: No | 2,407 |
| Jun 2020 | SEATS | PASSENGER MIDDLE ROW CAPTAIN CHAIR WAS NOT LOCKED IN PLACE RESULTING IN CHILD OCCUPANT TO BE PROPELLED FROM SEAT IN REAR MOST POSITION ALL THE WAY TO FRONT MOST POSITION WHILE ABRUPTLY BRAKING CAUSING CHILD TO STRIKE REAR OF PASSENGER FRONT SEAT. UPON DEALERSHIP INSPECTION WE WERE INFORMED THAT THERE IS A TSB THAT STATED IF THE BATTERY IS DISCONNECTED OR DEAD FOR A PERIOD OF TIME REPROGRAMMING OF THE DOOR CONTROL MODULE WOULD BE REQUIRED TO RESET. PREVIOUS TO INCIDENT DEALER HAD DISCONNECTED BATTERY FOR REPLACING DOOR WINDOW SWITCH AND RETURNED VEHICLE TO US WITH THIS PROBLEM. THERE WAS NO WARNING OR INDICATION THAT THIS SEAT WAS UNSAFE TO BE OCCUPIED AND THAT REPROGRAMMING OF DOOR MODULE REQUIRED. ON TOP OF THE SAFETY CONCERN THIS WOULD ALSO MEAN THAT IF REPLACING A BATTERY YOU WOULD REQUIRE FORD TO SAFELY PERFORM THIS. SOMEONE IS GOING TO GET SERIOUSLY HURT HERE AND OBVIOUSLY FORD KNOWS ABOUT THE ISSUE WITH TSB RELEASED. *TR | Crash: No Fire: No | 4,000 |
| Jun 2020 | ELECTRICAL SYSTEM | THE VEHICLE WAS DRIVING ON A LOCAL HIGHWAY WHEN THE MESSAGE 'SERVICE CHARGE SYSTEM NOW'. THE BATTERY ICON APPEARED BRIEFLY ON THE DASHBOARD. I CONTINUED DRIVING AND THE SAME MESSAGE REAPPEARED EVERY 5 MINUTES. THE DEALER TOLD ME THEY DID NOT RECOGNIZE THE MESSAGE, AND TO BRING THE VEHICLE IN FOR SERVICE SOON. THEY RAN A 'DIAGNOSTIC ' AND DETERMINED IT NEEDED A NEW ALTERNATOR. THE VEHICLE IS SEVEN MONTHS OLD AND HAS LESS THAN 15,000 MILES. IT IS STILL IN FOR SERVICE AS THE DEALER DID NOT HAVE A REPLACEMENT ALTERNATOR IN STOCK. *TR | Crash: No Fire: No | 15,000 |
| Jun 2020 | ELECTRICAL SYSTEM | TL* THE CONTACT OWNS A 2020 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE INSTRUMENT PANEL STATED THAT THE VEHICLE WAS DRIVING AT 85 MPH. THE SERVICE ENGINE SOON WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO GEWEKE FORD LOCATED AT 871 E. ONSTOTT RD, YUBA CITY, CA 95991, (530) 821-2121, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT AN UNKNOWN ELECTRONIC COMPONENT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 12,000. | Crash: No Fire: No | 12,000 |
| Jun 2020 | POWER TRAIN | STRONG JERKING WHEN SLOWING FOR CORNER OR STOP SIGN...SUDDEN ABRUPT DOWNSHIFTING. TRANSMISSION FAILURE AT 8,500. TOLD THAT A RING OR CLIP IN THE TRANSMISSION HAD BROKEN, ALLOWING SOME PARTS TO MOVE FORWARD. CURRENTLY WAITING FOR A COMPLETE TRANSMISSION REPLACEMENT, BUT TRANSMISSIONS ARE EVIDENTLY BACK-ORDERED. *TR | Crash: No Fire: No | 8,500 |
| Jun 2020 | POWER TRAIN,SERVICE BRAKES | HAS HAPPENED TO ME A FEW TIMES. FOOT ON BRAKE, PUT THE CAR IN GEAR AND IT STARTS ROLLING. BRAKE PEDAL WON'T DEPRESS ANY FURTHER, BUT IT DEFINITELY WAS NOT ALL THE WAY IN, ALMOST LIKE IT WAS LOCKED OR SOMETHING. ONLY WAY TO GET IT TO STOP IS TO PUT IT BACK IN PARK OR NEUTRAL AND LET OFF THE BRAKE. *TR | Crash: No Fire: No | 10,000 |
| May 2020 | VISIBILITY,STRUCTURE | DRIVER DOOR AND WINDOW VIBRATING WHEN REAR WINDOWS ARE ROLLED DOWN IN EXCESS OF 40 MPH. *TR | Crash: No Fire: No | 1,400 |
| May 2020 | TIRES,WHEELS | MY 2020 FORD EXPLORER WHICH I PURCHASED A WEEK AGO AND IS EQUIPPED WITH HANKOOK KINERGY GT TIRES HAS ME ALL OVER THE ROAD WHEN TRAVELING ON THE FREEWAY AT SPEEDS ABOVE 55 MILES PER HOUR ON STRAIGHT AWAYS ALONG WITH CURVES. IT IS DANGEROUS BECAUSE WITH SHORT NOTICE THE VEHICLE WILL DRIFT TO THE LEFT OR RIGHT BECAUSE OF THE QUALITY OF THE TIRES, UPON FURTHER INVESTIGATION IT APPEARS THAT MANY OTHERS THAT HAVE VEHICLE'S WITH THESE TIRES EXPERIENCE BLOW-OUTS, UNEVEN WEARING, AND COMPLAINTS ABOUT RIDE QUALITY. *TR | Crash: No Fire: No | 267 |
| May 2020 | ENGINE | I WAS DRIVING TO WORK AND SUDDENLY HEARD A STRANGE SOFT REPETITIVE NOISE. THERE WERE NO INDICATOR LIGHTS/WARNINGS ON THE DASH. I WAS GOING APPROXIMATELY 40 MPH AND THANKFULLY DECIDED TO PULL OVER INTO THE SERVICE LANE. THE VEHICLE STRUGGLED TO PULL OVER AND THEN STOPPED MOVING. AN ENGINE MALFUNCTION INDICATOR LIGHT THEN CAME ON. THE VEHICLE WAS TOWED BY THE DEALERSHIP. I WAS TOLD LATER THAT DAY THAT THE ENGINE WAS END OF LIFE, IN OTHER WORDS, DEAD. MY 2020 EXPLORER HAD 7,038 MILES. I FINALLY GOT MY SUV BACK 1 MONTH LATER. *TR | Crash: No Fire: No | 7,038 |
| May 2020 | SEATS,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES | WHILE I WAS DRIVING ON THE INTERSTATE, IN THE LEFT MOST LANE, THERE WAS ROAD ON THE SIDE OF THE ROAD SIGHTED AHEAD THAT WAS EXTENDING INTO THE LEFT LANE I WAS TRAVELING IN. TO AVOID THE UPCOMING LANE INFRINGEMENT, I NEEDED TO ACCELERATE TO CHANGE LANES TO THE RIGHT OF ME. I HAD PLENTY OF ROOM TO EXECUTE EVASIVE MANEUVERS; THE 2020 EXPLORER ST HOWEVER, DID NOT ALLOW ME TO CHANGE LANES AND INSTEAD APPLIED THE BRAKES AND FROZE MY ABILITY TO STEER - ALMOST CAUSING AN ACCIDENT. THIS HAS HAPPENED TWICE ON THE INTERSTATE. I TOOK THE VEHICLE TO FORD - NO EXPLANATION/CANNOT FIND A PROBLEM. THE VEHICLE ALSO UNEXPECTEDLY BREAKS WHEN NOTHING IS NEAR IT. THIS ALSO HAPPENS IN REVERSE. THE CAR WILL NOT LET ME REVERSE OUT OF MY GARAGE - NOTHING IS ANYWHERE NEAR IT!!! I HAVE TO TURN THE CAR OFF AND RESTART IT TO CLEAR ITS SENSORS. NOTHING IS THERE!!! I HAVE HAD THE CAR ABOUT 7 MONTHS AND ONLY HAVE ABOUT 2000 MILES ON THE CAR. I'M AFRAID TO DRIVE IT AND WANT TO RETURN IT. THE SENSORS ARE OBVIOUSLY MALFUNCTIONING. THE VEHICLE WILL NOT REMEMBER SEAT SETTINGS OR MIRROR SETTINGS. IT ALSO INADVERTENTLY CHANGES THE SEAT LOCATION WHILE GOING FROM PARK TO DRIVE OR SITTING AT A LIGHT AND PUSHES IT ALL THE WAY FORWARD RAMMING MY KNEES/LEGS INTO THE DASH.... IT WILL NOT STOP GOING FORWARD UNLESS I TURN THE VEHICLE COMPLETELY OFF. THIS IS DEFINITELY A MALFUNCTION. I HAVE TAKEN IT TO FORD DEALER SERVICE - THEY CANNOT FIND A PROBLEM. *TR | Crash: No Fire: No | Unknown |
| May 2020 | SERVICE BRAKES | PERIODICALLY, AFTER STARTING THE VEHICLE, AND SELECTING A GEAR (EITHER DRIVE OR REVERSE), I EXPERIENCE A "HARD BRAKE" WHERE I CANNOT PRESS DOWN THE BREAK PEDAL BUT THE VEHICLE WILL BEGIN TO ROLL. THE VEHICLE WILL CONTINUE TO ROLL AND I CANNOT USE THE BRAKE PEDAL (THEREFORE I CANNOT STOP). THE ONLY SOLUTION I HAVE FOUND IS TO SWITCH THE VEHICLE TO PARK, TURN OFF THE VEHICLE, AND TURN BACK ON THE VEHICLE. THIS HAPPENS APPROXIMATELY 2 TIMES PER MONTH. THE 2020 FORD EXPLORER USES AN ELECTRIC BRAKE BOOSTER, AND I BELIEVE IT MAY BE A CALIBRATION ISSUE UPON IGNITION/VEHICLE START UP. IF IT DOES NOT CALIBRATE PROPERLY, THE BRAKES WILL NOT WORK. THIS IS A COMMON ISSUE, AND THERE IS A THREAD AT THE EXPLORER FORUM WITH VARIOUS MEMBERS EXPERIENCING THIS SAFETY ISSUE. YOU CAN FIND THE THREAD, AND STATEMENTS FROM OTHERS, AT THE BELOW WEBPAGE: HTTPS://WWW.EXPLORERFORUM.COM/FORUMS/THREADS/BRAKE-ISSUE.483026/ *TR | Crash: No Fire: No | 2,000 |
| May 2020 | ELECTRICAL SYSTEM | SINCE WE HAVE PURCHASED THE SUV IT HAS ON MULTIPLE OCCASIONS FLASHED CROSS TRAFFIC SYSTEM FAULT, BLIND SPOT SYSTEM FAULT, AC SHUTS OFF, AND THE WINDOWS WILL NOT ROLL DOWN. HAVE TAKEN TO THE DEALERSHIP TWICE, ONCE THEY CHARGED THE BATTERY, THE LAST TIME THEY RESET A MODULE. IT DID IT AGAIN TODAY SO WE WILL HAVE TO TAKE IT BACK. WE HAVE HAD THE PROBLEM HAPPEN WHILE MOVING BUT TODAY WE WERE STATIONARY WHEN IT HAPPENED. *TR | Crash: No Fire: No | 1,210 |
| May 2020 | UNKNOWN OR OTHER | IMMEDIATELY AFTER STARTING VEHICLE (IN GARAGE) AND WHILE IT WAS STILL IN PARK, I SAW WHITE SMOKE RISING UP TO THE DRIVER SIDE VISOR. IT LOOKED AS IF THE SMOKE HAD COME FROM THE DRIVER SIDE WINDOW DEFROSTER VENT. AS A RESULT, I TURNED OFF THE VEHICLE AND WENT TO GRAB THE FIRE EXTINGUISHER. I LET THE VEHICLE SET FOR A COUPLE OF MINUTES AND THEN PULLED IT OUT OF THE GARAGE; HOWEVER, I DID NOT NOTICE ANY MORE SMOKE WHEN I MOVED IT. *TR | Crash: No Fire: No | 896 |
| Apr 2020 | ELECTRICAL SYSTEM | CAR GOES INTO DEEP SLEEP AFTER TWO DAYS OF BEING PARKED AND HAS TO BE JUMPED TO START. HAPPENS ON REGULAR BASIS. DEALER UNABLE TO CORRECT PROBLEM AFTER NUMEROUS ATTEMPTS TO REPAIR THE CAR SINCE IT WAS PURCHASED. | Crash: No Fire: No | 6,500 |
| Mar 2020 | STEERING | WHEN OUTSIDE TEMP IS BELOW MINUS 5 DEGREES STEERING IS HARD, AT SLOW SPEED STEERING LOCKED HAD TO JERK IT TO CONTROL. ABOVE 60MPH STEERING OK. HAPPENED AT PARKING LOT SPEED (LOCKING UP) AND BELOW 60MPH HARD STEERING. | Crash: No Fire: No | 1,000 |